How to maintain the winter dumper semi-trailer battery? Hongsheng Vehicle Technology Division

How to maintain the winter dumper semi-trailer battery? What are some of the most common problems that arise from the battery of the Hongsheng Vehicle Technology Division winter dump semi-trailer? Shandong Hongsheng Vehicle Technology Department answered the questions for your self-unloading semi-trailer battery. Why the battery is not powered? After the flameout, many of the dump semi-trailers and parts are still in operation. Many owners think that after closing the switch, the unloading half The trailer is in a stopped state. In fact, many devices are still in operation. Commonly used are many anti-theft system models, as long as the car locks the door, the system begins to enter the working state, the power consumption is much smaller than the headlights and other equipment. But after a few weeks, in the car for a long time without charging, the battery storage condition is poor, and the battery will be dead.

In the traditional impression, as long as the car key switch is turned off, all the parts of the dump semitrailer are stopped. However, if the engine temperature is too high, even if the dump semitrailer is turned off, the vehicle key gets off and the cooling system will automatically start. Only when the temperature of the engine system decreases, the cooling system will automatically stop working, usually within 3 to 5 minutes. When you lock your car, forget to turn off the lights. How do you maintain the battery in winter? Hongsheng Vehicle Technology Division

The lights were turned off and the batteries were over-used and they finally went on strike. Nowadays, there are many vehicle headlights that automatically lock the car, but there are still some cars that need to manually turn off the headlights, so remember to turn off the lights to better extend battery life.

What are the precautions for using the battery in winter? 1. When the battery is not used for a long time, it will slowly release electricity on its own. Therefore, the battery should be charged at regular intervals. 2, to avoid a long time parked in public outdoor, you must remove the battery to prevent damage to the battery icing.

3, the battery's storage capacity can be reflected in the dashboard. When the current meter pointer shows that the storage capacity is insufficient, charge in time.

4. Add distilled water or special rehydration solution to the electrolyte. Never use pure drinking water instead. Because water contains multiple trace elements, the battery will cause adverse effects. 5. Each time you want to clean the battery terminals, and coated with a special grease protection harness, check the battery connection accessories and connections.

6, the daily route should be regularly checked whether the battery cover vents, if the battery cover hole obstruction, resulting in hydrogen and oxygen line expansion of the electrolyte, the battery shell rupture, affecting the battery life.

7. The use of self-unloading semi-trailer appliances is forbidden after the engine. The use of the self-unloading semi-trailer battery without electricity will cause damage.

8, check each part of the circuit is not aging or short circuit to prevent early retirement of the battery, because of excessive emissions. The dump trucks are divided into two types: tipping and lateral tilting. Through the control of the piston rod, the rearward tilting is more common. The piston rods are tilted to make the cars tilt and a few bidirectional dumps.

The high-pressure oil enters the lift cylinder through the distribution valve and tubing, and the cabin safety protection board is at the front of the compartment.

The engine drives the hydraulic pump through the transmission and force-retrieving device. The hydraulic tilting mechanism of the compartment is composed of a fuel tank, a hydraulic pump, a distribution valve, a lifting hydraulic cylinder, a control valve and a fuel pipe. How to maintain the winter dumper semi-trailer battery? Hongsheng Vehicle Technology Division

The engine drives the hydraulic pump through the transmission and power take-off device. High-pressure oil enters the lift cylinder through the distribution valve and the oil pipe, and pushes the piston rod to tilt the carriage. Tipping is more common in the future. Controlling the piston rod movement by the operating system can stop the car at any desired tilt position. The carriage is reset using its own gravity and hydraulic control. Its advantages include the fact that the loading compartment can automatically tip and discharge at a certain angle, greatly saving the time and labor for unloading, shortening the transportation cycle, increasing the production efficiency, and reducing the transportation cost. It is a commonly used transportation-specific vehicle.

New dump trucks or overhauled vehicles must be commissioned so that the lifting process of the carriage can be smoothly and smoothly. When used, all parts should be properly selected according to the provisions of lubricating oil, greatly saving the unloading time and labor, lifting agencies strictly on schedule oil exchange. Loaded according to rated load, no overloading is allowed. Shandong Hongsheng Vehicle Special Purpose Manufacturing Co., Ltd. provides professional, comprehensive special car prices, semi-trailer pictures. Perennial production of light-duty unloading semi-trailer, standard after-loading unloading semi-trailer, heavy-duty unloading semi-trailer, unloading unloading semi-trailer after 8 meters, unloading semi-trailer after 8.5 meters, 9 meters, 9.5 meters Self-unloading semi-trailer, turn-over semi-trailer after project, light side dump

9. In general, the battery life of a dump truck is approximately 2 to 3 years. However, a modified dump semi-trailer device can generally destroy the life of a battery. In winter, it is often necessary to check whether the battery is operating normally. How to maintain the winter dumper semi-trailer battery? Hongsheng Vehicle Technology Division